Product ID:SCF 1590, 07333.3
MSDS Date:06/26/1990
FSC:9150
NIIN:00N019010
MSDS Number: BLDRH

PENNWALT CORPORATION

2375 STATE ROAD
CORNWELLS HEIGHTS, PA 19020
US

Emergency Phone: 215-245-3128 800-424-9300(CHEMTREC)

Info Phone: 215-245-3128

Cage: 7K913

PENNWALT CORPORATION/ELF ATOCHEM NORTH AMERICA

PHILADELPHIA, PA 19102 US

Telephone: 215-587-7711

Cage: 7K913

HEXYLENE GLYCOL

CAS: 107-41-5

RTECS: SA0810000

OSHA PEL C 25 PPM

ACGIH TLV: C 25 PPM; 9192

MINERAL OIL, PETROLEUM DISTILLATE, HYDROTREATED HEAVY

CAS: 64742-52-5

RTECS: PY8035000

OSHA PEL 5 MG/M3

ACGIH TLV: 5MG/M3;10 MG/M3 STEL

ANIMAL FATTY OIL; (LARD OIL)

CAS: 8016-28-2

SULFONIC ACIDS, PETROLEUM, SODIUM SALTS; (SODIUM SULFONATE)

CAS: 68608-26-4

RTECS: WR7150000

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITANT. SKIN: IRRITANT.
PROLONGED OR REPEATED SKIN CONTACT WITH THIS PRODUCT TENDS TO
REMOVE SKIN OILS, POSSIBLY LEADING TO IRRITATION AND DERMATITIS.
HOWEVER, BASED ON HUMAN EXPERIENCE AND AVA ILABLE TOXICOLOGICAL
DATA, THIS PRODUCTIS JUDGED NOT TO BE A SKIN IRRITANT BY OSHA
STANDARDS.
Explanation of Carcinogenicity:NAPHTHENIC OIL CAS NO 64742-52-5. LISTED
BY RTECS AS AN IARC GROUP1 CARCINOGEN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/BREATHING DIFFICULTY
MAY FIND EXPOSURE TO THIS PRODUCT INCREASES THAT DIFFICULTY. SUCH
INDIVIDUALS SHOULD PAY SPECIAL ATTN TO THE RECOMMENDED EXPOSURE
LIMITS FOR HAZARDOUS INGREDIENTS.

First Aid:INGEST: DO NOT INDUCE VOMIT. GIVE PLENTY OF H2O OR MILK. GET
EMERGENCY MEDICAL TREATMENT. SKIN: WASH WITH SOAP AND WATER. GET
MEDICAL ATTENTION. REMOVE AND LAUNDER CONTAMINAED CLOTHING. EYE:
FLUSH WIT H PLENTY OF WATER FOR AT LEAST 15 MIN. HOLD EYELIDS OPEN
WHILE FLUSHING. GET MEDICAL ATTENTION. INHAL: REMOVE TO FRESH AIR.
IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION.

Flash Point Method:COC
Flash Point:375F,191C
Extinguishing Media:CO2, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY CAUSE FROTHING. WEAR NIOSH/MSHA
APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT . COOL FIRE EXPOSED
CONTAINERS WITH WATER.

Spill Release Procedures:ABSORB WITH SAND OR INERT MATERIAL. SWEEP OR
SCOOP UP AND REMOVE. FLUSH RESIDUE, WITH WATER, TO CHEMICAL WASTE
TREATMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING. DO NOT
GET IN EYES, ON SKIN OR CLOTHING. DO NOT BREATHE DUST, VAPOR, MIST
OR GAS. KEEP CONTAINER CLOSED.
Other Precautions:MINIMUM CONTACT WITH THIS AND ALL CHEMICALS IS
RECOMMENDED AS A GOOD GENERAL POLICY TO FOLLOW.

Respiratory Protection:RESP PROT SHOULD BE WORN IF LEVEL OF AIRBORNE
CONTAM EXCEEDS LEVELS (S) LISTED. AIR QUALITY SHOULD ALWAYS BE
IMPROVED FIRST BY ENGINEERING SOLUTIONS (SUCH AS BETTER VENT), &
THEN BY USING RESP PROT IF ENGINEERING SOLUTION IS UNSUCCESSFUL.
Ventilation:MAINTAIN VENT SUFFICIENT TO REDUCE THE LEVEL OF HAZARDOUS
INGREDIENT (S) BELOW THE STATED CONCENTRATION LEVEL (S).
Protective Gloves:ANY NON-PERMEABLE TO PROD. (SUPP DATA)
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
CNDTN (STAB): NITRTOSOAMINES HAVE BEEN SHOWN TO CAUSE CANCER IN
LABORATORY ANIMALS AND ARE SUSPECT HUMAN CARCINOGENS. PROT GLOVE:
NEOPRENE OR NITRILE TYPE GLOVES ARE RECOMMENDED WHERE PROLONGED OR
REP EATED EXPOSURE IS ANTICIPATED. THIS PRODUCT, BECAUSE OF ITS
DETERGENCY, MAY BE A SKIN DEFATTER.

HCC:V6
Boiling Pt:B.P. Text:>200F,>93C
Vapor Pres:NIL
Spec Gravity:0.93
Solubility in Water:SOLUBLE
Appearance and Odor:FAINTLY HAZY, AMBER, MEDIUM VISCOSITY FLUID.
Percent Volatiles by Volume:< 5

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND STRONG OXIDIZERS.
Stability Condition to Avoid:CNTNS ORGANIC AMINE CMPDS. NITRITE BASED
MATLS SHOULD NOT BE ADDED DUE TO POSSIBLE NITROSOAMINE FORMATION.
(SUPP DATA)
Hazardous Decomposition Products:THERMAL-OXIDES OF CARBON, NITROGEN AND
SULFUR COMPOUNDS.

Waste Disposal Methods:LANDFILL OR INCINERATION. CONSULT FEDERAL,
STATE, OR LOCAL AUTHORITIES FOR PROPER DISPOSAL PROCEDURES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.